Justin & Meredith Winokur's Kitchen Cooking Notebook
Our Recipe Book ·
Steven's Recipe Book ·
Ann's Recipe Book ·
Meal Ideas ·
Random · Random Links
Home > posts > 2023 > 01 > 2023-01-22_Smoked_Brisket.html
Smoked Brisket -- Two Ways
Links are to the current pages which may not exist or have changed.
ID-based links may not work. Internal links have [@rev] links to this revision
?rev=5c0c169f to a URL.
See the help page for more information.
My friend gave me his old pellet smoker and I finally got around to testing it out. I wanted to compare doing it 100% on the smoker vs sous vide then finished on the smoker. I trimmed a full packer brisket and then cut it length wise. I sous vide the first half and then I did the second on the smoker.
BLUF1: I am almost certain I messed up with the smoker and it universally ran too hot. Everything about how they both came out fits this possibility. It is possible it is just observation bias but I do not think so. I think I messed up.
I followed the Sous Vide Smoked Brisket Recipe [Serious Eats][@rev] to make a simple rub of just kosher salt and pepper. It was 3 oz of peppercorns and 3.5 oz of kosher salt. I cut them both on Saturday. The priced weight was 15.74 lbs though I didn't confirm it. I trimmed off 2 lbs 13.125 oz. I did not weigh any liquid or the bag.
On Saturday, the day before, I coated the brisket (6 lbs 8.75 oz) and vacuum sealed it. Since I have been kind of unhappy with the sealer, I did two seals (each a double) on both sides of the bag. I also made it super large to give myself lots of room.
I sous vide cooked it at 155°F for about 25.75 hrs.
I then put it on the smoker (see note about the smoker below) at 175° around 3:00pm on Sunday and then moved set it to 215°F at 4:00. I took it off around 5:30 pm. I wrapped it and let it sit in the cooler for an hour
It was pretty cooked at this point. You can see it in the photos above.
I followed Smoked Brisket [Traeger][@rev]
This was a struggle. On Sunday morning, I started the smoker around 7:15 (after going nuts trying to understand the setup. It just could not get to temp. I set it at 225°F and it couldn't climb above ~170°F. Fast forward, it was probably on the direct heat mode meaning it was actually much hotter but wasn't reading properly.
Anyway, while this was heating up, I coated the other half. This was a mistake according to the guide. I should have done it the night before when I did the sous vide one. Oops. Still, it got to sit for about 1.5 hours while I waited for the grill.
I finally gave up and decided to start it on the smoker and I could always do the post-wrap in the oven since thats less about smoke. Putting a towel over the smoker about an hour later which also helped a bit.
The meat temp climbed and climbed fast:
I wrapped it at 11:15 and put it back in until 1:00pm where it then was left to rest in the cooler until 6:30pm
As you can see THIS MUST HAVE BEEN TOO HOT.
Again, it could be observation bias but I think it was too hot.
The sous vide one was way overcooked on the outside. Beyond bark. You can see it in the photos. I needed to use a serrated knife and it still didn't cut well.
The regular cut well, had a nice smoke ring, but was dry.
In the guide book, it turns out it that it says something about the holes of the tray and a direct flame. I think I have them open. Not only that but cleaning it was insanely hard! Then my friend told me to wrap that in foil to cover the holes and make cleanup easier! I think everything ran way too hot and with some amount of direct flames.
First of all, I will wrap the tray in foil to make clean up easier and avoid issues with direct flames!
I am interested in comparing sous vide again but honestly, for the sake of simplicity, I may just do the smoked one whole. I will also be trying other meats first so hopefully I will have all of the kinks worked out.
Bottom Line Up Front ↩